Aerocar International's Aerocar (often called the Taylor Aerocar) is an American roadable aircraft designed and built by Moulton Taylor in Longview, Washington in 1949. Although six examples were made, it never entered large-scale production. It is considered one of the first practical flying cars.

Design and development

Taylor began designing a roadable aircraft in 1946. During a trip to Delaware, he met inventor Robert E. Fulton, Jr., who had designed an earlier roadable airplane, the Airphibian, with detachable wings. Taylor's prototype, the Aerocar, utilized folding wings that allowed the road vehicle to be converted into flight mode in five minutes by one person. When the rear license plate was flipped up, the operator could connect the propeller shaft and attach a pusher propeller. The same engine drove the front wheels through a three-speed manual transmission. When operated as an aircraft, the road transmission was left in neutral (though backing up during taxiing was possible by the using the reverse gear). On the road, the wings and tail unit were towed behind the vehicle. Taylor also put the propeller on the back of the car so it did not have to be removed when the Aerocar went on the road. and had a top airspeed of 110 miles per hour. An early-1950s "Industry on Parade" film shows Taylor driving and piloting his Aerocar, as well as footage of manufacture.

Testing and certification

The Civil Aeronautics Administration (CAA) granted the Aerocar civil certification in 1956, and Taylor reached a deal with Ling-Temco-Vought for serial production provided he could obtain 500 orders. When he was able to obtain only half that number, production plans ended. Only six examples were built. One is still flying as of 2008, and Taylor rebuilt another into the only Aerocar III.

Produced examples

There are four Aerocar Is, one Aerocar II, and one Aerocar I that was rebuilt as Aerocar III.

N4994P

thumb|Aerocar at the [[EAA AirVenture Museum]]

N4994P (1949, originally N31214) is yellow with silver wings. It was the very first Aerocar and is on display at the EAA AirVenture Museum in Oshkosh, Wisconsin. It is maintained in flying condition but is not flown.

N101D

thumb|1954 Taylor Aerocar Serial Number 3 registered as N101D

N101D (1954) is owned by Greg Herrick's Yellowstone Aviation Inc.

N102D

N102D (1960) is yellow and green. The last Aerocar built and the only one still flying, it is owned by Ed Sweeney and is on display at the Kissimmee Air Museum located at the Kissimmee Gateway Airport in Kissimmee, Florida. N102D was the only Aerocar built with the larger O-360 Lycoming powerplant giving it much better performance. It is the only road legal and driven Aerocar left. It is currently flown by the owner's son Sean Sweeney. It was previously owned by actor Bob Cummings, who used it in his TV sitcom The New Bob Cummings Show.

N103D

N103D (1956) has been repainted to red/black with red wings. It has been owned by Carl Felling and Marilyn Stine of Grand Junction, Colorado since 1981. It once flew Fidel Castro's brother, Raúl Castro, in Cuba. and Alan Maris. Scotty Wright reports Nutsch having 350 flying hours in N103D performing AIRWATCH duty. Traffic reporting was from 7:00 AM–8:30 AM and 4:30 PM–6:00 PM. During the Aerocar's AIRWATCH missions, it was painted white with red hearts and had the letters KISN on the top and bottom of the wings.

The aircraft was equipped with an emergency police/fire receiver for use in reporting emergency events on KISN radio stations broadcast. When flown for KISN it was based at Wik's Air Service, Hillsboro Airport (HIO), Hillsboro Oregon. On one of its more eventful flights for KISN it survived the Columbus Day Storm of 1962 without damage after its evening traffic reporting flight. W. John Jacob was piloting the aircraft at that particular time and should be credited with the successful landing during extreme wind conditions (perhaps more than 100 mph), but Ruth Wikander, who was in the aircraft to assist him, received the acclaim. Ruth Wikander was an active member of the 99's, the International Organization of Women Pilots. In 1962 Ruth Wikander drove the Aerocar as an automobile while trailering the wings in the annual Portland Rose Festival parade. The Aerocar was an integral part of KISN Radio along with photos of famous rock musicians and KISN DJs of the times.

Last flown in 1977, the aircraft is no longer airworthy and has been in storage ever since. It is not a roadable aircraft but is based on the original Aerocar design. It uses the wing and tail section from the Aerocar. It seats four and is powered by a 150 hp IO-320 Lycoming engine. Only a single example was built. As of 2006, it was located in Colorado Springs, Colorado owned by Ed Sweeney, the owner of N102D. The four retractable wheels are extended for takeoff and landing, partly retracted for road travel, and fully retracted in flight. Taylor attracted some interest from Ford in the Aerocar III, but no production resulted. The single prototype is displayed at Seattle's Museum of Flight with the registration N100D.

Specifications (Aerocar I)

References

;Notes

;Bibliography

  • Schultz, Jake. A Drive in the Clouds: The Story of the Aerocar . New Brighton, Minnesota: Flying Books International, 2006. .
  • Taylor, John W. R. Jane's All The World's Aircraft 1961–62. London: Sampson Low, Marston & Company, 1961.
  • Winchester, Jim. The World's Worst Aircraft: From Pioneering Failures to Multimillion Dollar Disasters. London: Amber Books Ltd., 2005. .
  • EAA AirVenture Museum's Aerocar
  • Text from Aviation Week 27 March 27, 1961.
  • Tired of the commute? All you need is $3.5 million- Aerocar for sale in September 2006
  • "Aerocar Goes Up for Auction." NPR, September 30, 2006.
  • N101D location
  • Jake Schultz Aerocar Film Collection at The Museum of Flight Digital Collections.
  • Roy A. Parsons Aerocar Film at The Museum of Flight Digital Collections.